本文選題：鉛鋅冶煉廢水中和渣　切入點：免燒免蒸磚　出處：《中國礦業》2017年S2期 　論文類型：期刊論文

【摘要】：以某鉛鋅冶煉廢水中和渣資源化綜合利用制備免燒免蒸磚。在原料主要化學成分分析、XRD物相分析及中和渣溶出和干燥凝結性能分析的基礎上,設計L16(4)5正交試驗,通過極差和方差分析得到不同制磚組分對免燒免蒸磚7d和28d強度的作用規律和制備免燒磚的最佳試驗配方,然后在最優配方下研究成型壓力和水灰比與免燒免蒸磚性能的關系。研究結果表明,影響免燒免蒸磚7d抗壓強度的配比組成用量因素排名為水泥、水渣微粉、混合中和渣、粉煤灰、石屑;影響免燒免蒸磚28d抗壓強度的配比組成用量因素排名為混合中和渣、水渣微粉、石屑、粉煤灰、水泥。最佳試驗配方為混合中和渣31.43%,水泥14.29%,水渣微粉31.43%,粉煤灰13.33%,石屑9.52%;最佳水灰比為0.14,合適的成型壓力為20MPa,最終制備的免燒免蒸磚28d抗壓強度為27.7 MPa,吸水率為11.5%,軟化系數為0.89,抗凍指標為F25,達到《〈非燒結垃圾尾礦磚〉》(JC422—2007)的標準要求。
[Abstract]:Based on the comprehensive utilization of neutralization and slag from a certain lead-zinc smelting wastewater to prepare non-fired non-steam brick, based on the analysis of the main chemical composition of raw materials, XRD phase analysis, dissolution and drying setting performance of neutralized slag, the orthogonal test of L16C4N5 was designed. By means of range difference and variance analysis, the effects of different brick components on the strength of non-fired non-steamed brick for 7 days and 28 days were obtained, and the optimum experimental formula for preparing unfired brick was obtained. Then the relationship between the molding pressure and the water-cement ratio and the properties of the non-fired non-steam brick was studied under the optimum formula. The results showed that the factors affecting the compressive strength of the non-fired non-steam brick in 7 days were cement, water slag powder, mixed neutralizing slag, and so on. The factors affecting the compressive strength of non-fired non-steam brick for 28 days are mixed neutralizing slag, water slag micro-powder, stone debris, fly ash, etc. Cement. The best test formula is mixed neutralizing slag 31.43um, cement 14.29, water slag micro-powder 31.43um, fly ash 13.33, stone debris 9.52. The optimum water-cement ratio is 0.14, the suitable molding pressure is 20MPa, and the final non-fired non-steam brick has 28d compressive strength of 27.7 MPa and water absorption ratio of 11.5mm. The softening coefficient is 0.89 and the freezing resistance index is F25, which meets the standard requirement of < < unsintered refuse tailings brick > > JC422-2007).
【作者單位】： 北京建筑大學;北京礦冶研究總院礦物加工科學與技術國家重點實驗室;
【分類號】：TU522.1;X758

【相似文獻】

相關期刊論文 前3條

1 孟昭華;西北冶煉廠可行性研究審批會議結束[J];硫酸工業;1984年06期

2 暮;池州鉛鋅冶煉廠銅冶煉及硫酸改造項目可行性研究暨擴初設計通過審查[J];硫酸工業;1993年04期

3 董四祿;西北鉛鋅冶煉廠除汞技術[J];硫酸工業;1997年05期

，

本文編號：1642408