α-胺基酸型捕收劑合成及其浮選應用研究
本文選題:膠磷礦 + 兩性捕收劑 ; 參考:《武漢工程大學》2015年碩士論文
【摘要】:隨著磷礦資源的不斷開采,易選礦越來越少,難選磷礦越來越多,這類難選磷礦主要為中低品位膠磷礦,由于其嵌布粒度細,有用磷礦與脈石礦物難以分離。目前的浮選磷礦物捕收劑脂肪酸及其鹽類已無法達到有效的捕收性能。通過對近年來不斷的浮選捕收劑研究,對其衍生化及其復配能極大的提高其浮選性能。同時對于兩性捕收劑在p H值7-10條件下,能作為方解石和白云石的陰離子捕收劑,而在p H值為6.5-4時,可作為氧化硅和硅酸鹽的陽離子捕收劑。考慮其既能用于正浮選,反浮選。同時又能大大減少藥劑成本,對其深入研究,能極大拓寬藥劑種類,解決礦石選礦技術難題。針對這一背景,本文以高級脂肪酸為原料,對其捕收劑合成進行試驗研究,并將其應用到中低品位難選膠磷礦的浮選中,達到了良好的浮選要求及指標。具體試驗內容如下:(1)以氯代油酸為原料(初始原料油酸),合成新浮選捕收劑HMA-1,將其作為正選捕收劑應用到抑硅浮磷浮選試驗中,對云南晉寧礦樣進行選別,將該礦樣從原礦品位20.25%,通過一步正選達到精礦品位24.28%,產率80.86%,回收率93.3%的良好浮選指標。試驗表明其極大的改善了浮選氣泡性能,對浮選磷酸鹽有很好的促進作用。(2)以氯代油酸為原料(初始原料油酸),通過與氨氣、氨水,高壓反應,合成新浮選捕收劑HZA-1、HZA-2。將兩種捕收劑以放馬山礦樣為浮選礦樣進行對比浮選試驗,得出以氨水為原料其產率更高,且浮選性能更好。對于合成的HZA-2,由于其氨基、羧基的存在,可作為兩性捕收劑應用到浮選中。分別以正浮選銅陵礦樣、反浮選云南玉溪礦樣,對其浮選捕收性能進行研究。試驗結果表明,其在正、反浮選的應用中均表現出較好浮選性能。(3)對合成的捕收劑HZA-2,以放馬山低品位礦樣為試驗礦樣,對其進行系統分析與試驗,通過試驗與優化,得到最佳浮選工藝條件及指標性能。其從原礦14.96%通過“一正一反一掃”閉路浮選流程達到精礦品位28.21%,正尾品位7.31%,掃尾7.06%,精礦回收率70.05%的浮選指標。同時,將試驗所用廢水回收再利用,以回收的酸水、回水再次對其礦樣進行選別,研究對浮選的影響,試驗結果表明回水及酸水對試驗均有影響,但對小試試驗影響不大。(4)基于HZA-2對放馬山礦樣較好浮選性能及小試系統的浮選試驗,將其進一步對放馬山礦樣進行擴大噸級試驗。與小試浮選“一正一反一掃”工藝相同,通過對藥劑制度的調節,最后在閉路條件下達到精礦品位28.88%,正尾品位7.83%,掃尾品位7.61%的良好指標,同時與工廠藥劑成本對比,采用捕收劑HZA-2,平均每噸精礦節約30.51元,解決了其在常溫條件下達到浮選技術指標的同時降低浮選成本的技術難題。
[Abstract]:With the continuous exploitation of phosphate rock resources, less and less easy ore dressing, more and more refractory phosphate rock, this kind of refractory phosphate rock is mainly low grade colloidal phosphate rock, because of its fine size, useful phosphate rock is difficult to separate from gangue mineral. The current flotation phosphate collector fatty acid and its salts have not been able to achieve effective capture performance. Through the research on the flotation collector in recent years, its derivation and its compounding can greatly improve its flotation performance. At the same time, the amphoteric collector can be used as the anionic collector for calcite and dolomite at pH 7-10, and the cationic collector for silica and silicate at pH 6.5-4. It is considered that it can be used in both positive flotation and reverse flotation. At the same time, it can greatly reduce the cost of reagents, study them deeply, widen the kinds of reagents and solve the technical problems of ore dressing. In view of this background, this paper studies the synthesis of collector with high fatty acid as raw material, and applies it to the floatation of low and middle grade refractory colloidal phosphate ore, which meets the good flotation requirements and indexes. The specific test contents are as follows: (1) using chlorinated oleic acid as raw material (initial raw material oleic acid), a new flotation collector HMA-1 was synthesized, which was used as a positive collector in the flotation test of silicon suppression floating phosphorus, and the samples of Jinning mine in Yunnan Province were separated. The concentrate grade is 24.28%, the yield is 80.86% and the recovery rate is 93.3%. The experiment shows that the flotation bubble property is greatly improved and the flotation phosphate has a good promoting effect. The new flotation collector HZA-1 and HZA-2 is synthesized by reacting with ammonia, ammonia water and high pressure with chlorinated oleic acid as raw material (initial raw material oleic acid). The comparative flotation experiments were carried out with two kinds of collector. The results showed that ammonia was used as raw material to produce higher yield and better flotation performance. The synthesized HZA-2 can be used as amphoteric collector in flotation due to the presence of amino and carboxyl groups. The flotation and collection properties of Tongling ore samples and Yuxi ore samples were studied respectively. The test results show that both the positive and reverse floatation have better flotation performance. The synthetic collector HZA-2 is used as the test sample. The system analysis and test are carried out on the low grade ore sample of Mashan, and the experiment and optimization are carried out through the experiment and optimization. The optimum flotation conditions and properties were obtained. From the raw ore 14.96%, through the closed circuit flotation process of "one positive, one reverse and one sweep", the flotation indexes of concentrate grade 28.21, positive and tail grade 7.31, tail-sweeping 7.06 and concentrate recovery 70.05% are achieved. At the same time, the waste water used in the experiment is recycled and reused to separate the ore samples from the recovered acid water and backwater again, and the effect on flotation is studied. The test results show that both backwater and acid water have influence on the experiment. However, the effect on the small scale test is not significant. (4) based on the better flotation performance of Fomashan ore sample by HZA-2 and the flotation test of the small scale test system, the expanded tonnage test is carried out on the Fumashan ore sample. Same as the "one positive, one reverse, one sweep" process of small scale flotation. By adjusting the pharmaceutical system, the fine indexes of concentrate grade 28.88, positive grade 7.833% and tail-sweeping grade 7.61% are reached under closed circuit conditions, and at the same time compared with factory pharmaceutical cost, By using collector HZA-2, an average saving of 30.51 yuan per ton of concentrate is saved, which solves the technical problem of reaching the technical index of flotation at room temperature and reducing the cost of flotation.
【學位授予單位】:武漢工程大學
【學位級別】:碩士
【學位授予年份】:2015
【分類號】:TD923.13
【相似文獻】
相關期刊論文 前10條
1 嚴瑞芬;;硫氮九號捕收劑的制造[J];有色金屬(冶煉部分);1966年05期
2 ;磷礦浮選的兩種混合捕收劑[J];化工礦山技術;1982年03期
3 朱建光;磷礦捕收劑的進展[J];化工礦山技術;1988年02期
4 ;新型稀土捕收劑[J];江西有色金屬;1992年03期
5 劉述忠,李曉陽,徐曉軍,楊新華;捕收劑組合使用的研究概況[J];云南冶金;2002年04期
6 呂玉庭,王勁草,周國江,呂一波;煤油乳化捕收劑作用機理與應用[J];礦產綜合利用;2003年06期
7 韓春龍,劉金羽,侯亞飛;煤用乳化捕收劑的應用研究[J];選煤技術;2005年03期
8 劉文剛;魏德洲;周東琴;朱一民;賈春云;;螯合捕收劑在浮選中的應用[J];國外金屬礦選礦;2006年07期
9 徐博;;浮選捕收劑吸收性能研究[J];中國煤炭;2006年12期
10 李成吾;李勇;左繼成;劉艷輝;;磷礦捕收劑研究進展[J];有色礦冶;2007年02期
相關會議論文 前10條
1 梅建庭;赫榮安;;新型難選氧化鐵礦捕收劑的合成方法研究[A];2008年全國金屬礦山難選礦及低品位礦選礦新技術學術研討與技術成果交流暨設備展示會論文集[C];2008年
2 劉迎春;徐秋生;張美鴿;;0~#柴油作捕收劑選鉬試驗研究[A];2005年全國選礦高效節能技術及設備學術研討與成果推廣交流會論文集[C];2005年
3 崔廣文;王樂明;武江明;王京發;;新型捕收劑的試驗研究[A];2011年全國選煤學術交流會論文集[C];2011年
4 林強;楊曉玲;王淀佐;;全新螫合捕收劑α-肟基磷酸酯的合成及結構與性能關系[A];西部大開發 科教先行與可持續發展——中國科協2000年學術年會文集[C];2000年
5 王云飛;陳宏超;崔愫欣;張艷清;謝紅蓮;劉海波;崔濤;;8#藥捕收劑在生產實踐中的推廣運用[A];2012年中國稀土資源綜合利用與環境保護研討會論文集[C];2012年
6 俞娟;楊洪英;柴雙;;輝鉬礦浮選捕收劑的研究進展[A];有色金屬工業科技創新——中國有色金屬學會第七屆學術年會論文集[C];2008年
7 孫炳泉;樊紹良;;采用高效捕收劑提高貧紅鐵礦選礦效益的試驗研究[A];第四屆全國礦山采選技術進展報告會論文集[C];2001年
8 楊玉珠;;采用組合捕收劑提高銅礦石中金的回收率[A];有色金屬工業科技創新——中國有色金屬學會第七屆學術年會論文集[C];2008年
9 周為民;;某難選鉬礦粗選捕收劑的試驗研究[A];復雜難處理礦石選礦技術——全國選礦學術會議論文集[C];2009年
10 曾海鵬;雷主生;郭翔;劉鵬飛;葉豐;;新型捕收劑ZX-710在豐山銅礦的試驗研究[A];第三屆全國數字礦山高新技術成果交流會論文集[C];2014年
相關重要報紙文章 前5條
1 高會峰;沂南新型捕收劑通過半工業性實驗[N];中國黃金報;2008年
2 楊琴 李柏球;新型捕收劑研制成功[N];中國有色金屬報;2002年
3 桂靈;“甕福一號”捕收劑增效千萬元[N];中國化工報;2003年
4 張雪榕;金鉬集團兩項科技成果達國際先進水平[N];中國有色金屬報;2008年
5 湖北黃麥嶺磷化工集團公司 唐有運 王耀林;用新型捕收劑浮選低品位磷礦石[N];農資導報;2006年
相關博士學位論文 前10條
1 曹飛;基于密度泛函理論的硫氨酯捕收劑的設計合成及機理研究[D];北京科技大學;2016年
2 陳遠道;高效鋁土礦浮選捕收劑的研究與應用[D];中南大學;2007年
3 余新陽;新型有機硅陽離子捕收劑的合成及其對鋁硅礦物的浮選特性與機理研究[D];中南大學;2011年
4 袁露;新型硫化礦捕收劑的合成及其浮選性能研究[D];中南大學;2012年
5 蔣昊;鋁土礦浮選過程中陽離子捕收劑與鋁礦物和含鋁硅酸鹽礦物作用的溶液化學研究[D];中南大學;2004年
6 余侃萍;高磷鐵礦反浮選降磷捕收劑的研究與應用[D];中南大學;2013年
7 劉文剛;新型赤鐵礦反浮選脫硅捕收劑的合成及浮選性能研究[D];東北大學;2010年
8 劉長淼;鋁硅礦物的叔胺類捕收劑的合成、性能及作用機理研究[D];中南大學;2009年
9 葛英勇;新型捕收劑烷基多胺醚(GE-609)的合成及浮選性能研究[D];武漢理工大學;2010年
10 楊帆;季銨捕收劑在白鎢礦浮選中的應用及其作用機理研究[D];中南大學;2013年
相關碩士學位論文 前10條
1 高莉;白鎢礦浮選捕收劑的性能評價及浮選機理研究[D];江西理工大學;2015年
2 劉金亭;丹東鳳銀金礦浮選試驗研究[D];中國礦業大學;2015年
3 裴建;新型多胺類捕收劑的合成以及在鐵礦石脫硅反浮選中的應用[D];中國礦業大學;2015年
4 郭曉峰;新型席夫堿捕收劑的合成及對氧化銅礦浮選性能研究[D];中國礦業大學;2015年
5 高野;宣龍赤鐵礦焙燒磁選精礦反浮選的新型復合陰離子捕收劑研究[D];東北大學;2013年
6 李小婷;陽離子型聚苯乙烯納米粒子作為新型煤炭浮選捕收劑的試驗研究[D];太原理工大學;2014年
7 李振宇;利用化工廢液合成新型捕收劑應用研究[D];昆明理工大學;2015年
8 趙陽;低品位重晶石浮選工藝及捕收劑吸附機理研究[D];昆明理工大學;2015年
9 李梅禮;菱鎂礦正浮選中新型捕收劑的應用研究[D];遼寧科技大學;2015年
10 曹明強;聚苯乙烯納米粒子作為浮選捕收劑的試驗研究及機理分析[D];太原理工大學;2016年
,本文編號:1986014
本文鏈接:http://www.sikaile.net/kejilunwen/kuangye/1986014.html