基于非均勻入口條件的SCR氨噴射方法
發布時間：2018-11-24 21:08
【摘要】：為了提高選擇性催化還原(SCR)脫硝系統煙氣流場和還原劑濃度在反應器內分布的均勻性,以300MW四角切圓燃煤鍋爐SCR系統為原型,基于更符合SCR工程實際的非均勻入口邊界條件,采用數值模擬計算方法,分析不同氨噴射方法時還原劑的分布特性和標準偏差.結果表明:SCR入口NO通量偏差大,最大值為46.7%;彎道C布置4塊導流板時,E-E截面速度偏差系數從18.13%降低到13.61%;SCR入口采用渦流板均勻噴氨時,E-E截面氨氮比標準偏差系數Ch為17.52%,調整為非均勻噴氨時,Ch為15.56%,不均勻性效果改善不明顯;SCR入口采用噴氨格柵多噴嘴設置,且實行分區非均勻噴氨控制方法時,E-E截面的Ch降低至4.72%,對流場速度均勻性分布幾乎沒有影響,說明該方法是SCR系統還原劑有效控制方法.
[Abstract]:In order to improve the uniformity of flue gas flow field and reducing agent concentration in the selective catalytic reduction (SCR) denitrification system, the 300MW quadrangle tangential coal-fired boiler SCR system was used as the prototype. Based on the non-uniform inlet boundary conditions which are more in line with the actual conditions of SCR engineering, the distribution characteristics and standard deviation of reductant in different ammonia injection methods are analyzed by numerical simulation. The results show that the deviation of NO flux at the entrance of SCR is large, the maximum value is 46.7.The velocity deviation coefficient of E-E section decreases from 18.13% to 13.61 when the four guide plates are arranged in bend C. The standard deviation coefficient of ammonia nitrogen ratio of E-E section is 17.52 when the swirl plate is uniformly sprayed at the entrance of SCR, and the Ch is 15.56 when adjusted to non-uniform ammonia spray, the effect of inhomogeneity is not improved obviously. When the inlet of SCR is set with multiple nozzles with ammonia spray grille and the method of zone non-uniform ammonia spraying is implemented, the Ch of E-E section is reduced to 4.72, and the velocity uniformity distribution of the flow field has little effect on it. It shows that this method is an effective control method for reducing agent in SCR system.
【作者單位】： 東南大學能源熱轉換及其過程測控教育部重點實驗室;
【基金】：國家自然科學基金資助項目(51276038)
【分類號】：X773
本文編號：2355061
[Abstract]:In order to improve the uniformity of flue gas flow field and reducing agent concentration in the selective catalytic reduction (SCR) denitrification system, the 300MW quadrangle tangential coal-fired boiler SCR system was used as the prototype. Based on the non-uniform inlet boundary conditions which are more in line with the actual conditions of SCR engineering, the distribution characteristics and standard deviation of reductant in different ammonia injection methods are analyzed by numerical simulation. The results show that the deviation of NO flux at the entrance of SCR is large, the maximum value is 46.7.The velocity deviation coefficient of E-E section decreases from 18.13% to 13.61 when the four guide plates are arranged in bend C. The standard deviation coefficient of ammonia nitrogen ratio of E-E section is 17.52 when the swirl plate is uniformly sprayed at the entrance of SCR, and the Ch is 15.56 when adjusted to non-uniform ammonia spray, the effect of inhomogeneity is not improved obviously. When the inlet of SCR is set with multiple nozzles with ammonia spray grille and the method of zone non-uniform ammonia spraying is implemented, the Ch of E-E section is reduced to 4.72, and the velocity uniformity distribution of the flow field has little effect on it. It shows that this method is an effective control method for reducing agent in SCR system.
【作者單位】： 東南大學能源熱轉換及其過程測控教育部重點實驗室;
【基金】：國家自然科學基金資助項目(51276038)
【分類號】：X773
【相似文獻】
相關期刊論文 前7條
1 張毅;;超高壓凝析氣藏氣體偏差系數算法的確定[J];石油天然氣學報;2009年03期
2 張慶洲;樊建明;郭平;李俊杰;;非烴對氣藏流體偏差系數的影響[J];天然氣工業;2009年10期
3 袁自學;計算偏差系數經驗公式的優化選擇[J];新疆石油地質;1996年02期
4 張川如;非烴天然氣的偏差系數[J];石油與天然氣化工;1994年02期
5 N·J·Marshall;徐豐孚;;地球化學樣品中砷的比色測定[J];國外地質勘探技術;1981年10期
6 田文杰;牛文鐵;常文芬;張大衛;;數控機床幾何精度溯源方法研究[J];機械工程學報;2014年07期
7 ;[J];;年期
相關會議論文 前1條
1 韓波;司風琪;徐治皋;;“單位偏差系數”在運行優化系統中的應用[A];2004電站自動化信息化學術技術交流會議論文集[C];2004年
，本文編號：2355061
本文鏈接：http://www.sikaile.net/kejilunwen/huanjinggongchenglunwen/2355061.html
最近更新
教材專著
