本文關鍵詞： SRX穩定碎石 水穩定性 抗凍性 高溫穩定性　出處：《建筑材料學報》2017年04期 　論文類型：期刊論文

【摘要】：采用垂直振動方法成型水基聚合物SRX穩定碎石試件,研究了其強度增長規律.結果表明:當SRX摻量(質量分?jǐn)?shù))由0%增大到0.75%時,試件干化抗壓強度逐漸增大,最大為7.00MPa;繼續提高SRX摻量,試件干化抗壓強度出現下降的趨勢.通過飽水試驗、浸-烘循環試驗以及抗沖刷性能試驗,研究了SRX穩定碎石的水穩定性.結果表明:干化后的試件在浸水初期,其相對含水率急劇增大,當浸水36h時,試件基本達到飽水狀態,其相對強度約為76.0%;試件浸-烘循環30次和60次時,其殘留強度降低為93.8%和92.4%;隨著沖刷時間的延長,試件所承受的動水壓力增加,抗沖刷性能降低,最大質量損失為43.5g;在實驗室條件下SRX穩定碎石具有較好的水穩定性.通過5次凍融循環試驗和車轍性能試驗,研究了SRX穩定碎石的抗凍性能和高溫穩定性.結果表明:試件的抗凍系數約為10%,抗凍性能較差,不適宜在季凍地區應用;試件動穩定度達到ATB-30基層的5~6倍,展現出良好的抗車轍性能,適宜在高溫地區推廣應用.
[Abstract]:The vertical vibration method was used to form water-based polymer SRX stabilized macadam specimens, and the increasing rule of strength was studied. The results show that when the content of SRX (mass fraction) increases from 0% to 0.75, the dry compressive strength of the specimens increases gradually. The maximum value is 7.00 MPA. With increasing the content of SRX, the dry compressive strength of the specimen decreases. Through saturated water test, soak-drying cycle test and scour resistance test, The water stability of SRX stabilized macadam was studied. The results showed that the relative moisture content of the dried specimens increased sharply in the early stage of soaking, and when the specimens were immersed in water for 36 h, the water content of the specimens basically reached the state of saturation. The relative strength is about 76.0.The residual strength of the specimen decreases to 93.8% and 92.4 after 30 and 60 cycles of soaking and drying. With the extension of the scouring time, the dynamic water pressure and the erosion resistance of the specimen increase, and the erosion resistance of the specimen decreases with the extension of the scouring time. The maximum mass loss is 43.5 g. SRX stabilized crushed stone has good water stability under laboratory conditions. Through five freeze-thaw cycle tests and rutting performance tests, The freezing resistance and high temperature stability of SRX stabilized macadam are studied. The results show that the freezing resistance coefficient of the specimen is about 10, the frost resistance is poor, and the dynamic stability of the specimen is 5 ~ 6 times that of the ATB-30 base. It shows good rutting resistance and is suitable for application in high temperature area.
【作者單位】： 長安大學公路學院;河北省交通規劃設計院河北省道路結構與材料工程技術研究中心;金華市公路管理局;
【基金】：浙江交通科技項目(2013H18)
【分類號】：U414

【相似文獻】

相關期刊論文 前4條

1 時洪順;于丹;;公路土基抗凍性能的改善[J];黑龍江交通科技;2012年11期

2 王國忠,趙塵;瀝青穩定基層混合料抗凍性能正交試驗研究[J];內蒙古農業大學學報(自然科學版);2004年03期

3 楊揚;劉海蘋;;寒區ATPB基層抗凍性能研究[J];黑龍江工程學院學報;2008年02期

4 韓優良;;水泥粉煤灰穩定碎石的路用性能[J];交通世界(建養.機械);2012年05期

相關碩士學位論文 前2條

1 付二全;內蒙古嚴寒地區水泥混凝土路面抗凍性能試驗研究[D];長安大學;2015年

2 王利強;玄武巖纖維混凝土抗凍性能試驗研究[D];內蒙古工業大學;2014年

，

本文編號：1524653