雙進口兩級雙吸離心泵過渡流道壓力脈動特性研究
本文選題:兩級雙吸離心泵 + 雙進口。 參考:《農業機械學報》2017年02期
【摘要】:雙進口兩級雙吸離心泵的過渡流道由正流道、過橋段、反流道3部分組成,其中正流道為雙蝸殼型式,反流道為帶有導葉的雙螺旋型式,過橋段連接正反流道呈現空間扭曲狀。過渡流道與首級葉輪和次級葉輪均存在動靜耦合關系,由此導致的動靜干涉效應是引起壓力脈動的主要根源之一。采用CFD方法對雙進口兩級雙吸離心泵典型工況下的三維非定常流場進行了研究,對過渡流道壓力脈動機理進行了分析。研究發現,正流道內的靜壓分布與其雙蝸殼型式密切相關,在所有工況下均呈180°對稱分布,壓力脈動主頻均為葉片通過頻率,最大脈動幅值均出現在隔舌附近;小流量工況下,隔舌處壓力脈動主頻幅值明顯高于設計工況,約為設計工況的180%。在過橋段中,所有工況下壓力脈動主頻均為葉片通過頻率,設計工況下,沿著流動方向,內壁面進口處的壓力脈動主頻幅值達到最大,外壁面主頻脈動幅值變化沿流動方向有增加的趨勢;在反流道中,設計工況下壓力脈動主頻為葉片通過頻率,幅值沿著流動方向逐漸增加,出口處主頻的脈動幅值約為進口處的110%;小流量工況下,反流道導葉附近存在低頻成分,且在導葉周圍發現具有周期性的漩渦。
[Abstract]:The transition passage of double inlet two-stage double suction centrifugal pump consists of three parts: normal passage, bridge passage and backflow channel. The normal passage is a double volute type, the reverse channel is a double helical type with a guide vane, and the connecting positive and negative passage of the bridge has a space twist shape. There is a dynamic and dynamic coupling relationship between the transition channel and the first impeller and the secondary impeller, which is one of the main causes of pressure fluctuation. Three-dimensional unsteady flow field of double-inlet two-stage double-suction centrifugal pump under typical conditions was studied by CFD method. The mechanism of pressure pulsation in transition channel was analyzed. It is found that the static pressure distribution in the positive flow channel is closely related to its double volute type, and the distribution of pressure pulsation is 180 擄symmetry under all working conditions. The main frequency of pressure pulsation is blade passing frequency, and the maximum pulsation amplitude appears near the tongue. The main frequency amplitude of pressure pulsation in the tongue is obviously higher than that in the design condition, which is about 180 parts of the design condition. In the bridge section, the main frequency of pressure pulsation is the blade passing frequency under all working conditions. Under the design condition, the amplitude of the main frequency of pressure pulsation at the inlet of the inner wall reaches the maximum along the flow direction. The amplitude of the main frequency pulsation on the outer wall increases along the flow direction, and in the backflow channel, the main frequency of the pressure pulsation is the blade passing frequency, and the amplitude increases gradually along the flow direction. The pulsation amplitude of the main frequency at the outlet is about 110 at the inlet, and the low frequency component is found near the guide vane of the backflow channel under small flow conditions, and periodic swirls are found around the guide vane.
【作者單位】: 中國農業大學大學水利與土木工程學院;北京市供水管網系統安全與節能工程技術研究中心;上海連成集團有限公司;
【分類號】:TH311;;TV131.3+3
【相似文獻】
相關會議論文 前1條
1 叢國輝;王福軍;;雙吸離心泵隔舌區壓力脈動特性的數值研究[A];2009全國大型泵站更新改造研討暨新技術、新產品交流大會論文集[C];2009年
相關重要報紙文章 前1條
1 程軍;馬鋼二鐵總廠泵房節能改造省電30%[N];中國冶金報;2011年
相關博士學位論文 前4條
1 張自超;雙吸離心泵泥沙磨損特性研究[D];中國農業大學;2016年
2 冷洪飛;雙吸離心泵葉片載荷特性及其應用研究[D];中國農業大學;2015年
3 白耀華;雙吸離心泵內部流動模擬與輸水管道系統安全問題研究[D];武漢大學;2011年
4 張宇;大型雙吸式離心泵性能優化研究[D];華中科技大學;2014年
相關碩士學位論文 前10條
1 劉偉;24SH-19雙吸中開離心泵優化設計[D];沈陽大學;2015年
2 原雯;雙吸離心泵內部流場性能研究及優化設計[D];東北石油大學;2015年
3 陳凱;單級雙吸離心泵優化設計與試驗研究[D];江蘇大學;2016年
4 宋純純;雙吸泵數值模擬及介質和結構參數變化對其振動的影響[D];華東理工大學;2015年
5 楊亞威;隔舌對雙吸泵性能影響及其改型設計研究[D];蘭州理工大學;2012年
6 許驍;基于流場分析技術的雙吸泵性能優化研究[D];中國計量學院;2014年
7 陳奕文;雙吸中開式離心泵的優化設計方法研究[D];華中科技大學;2013年
8 王s,
本文編號:1873212
本文鏈接:http://www.sikaile.net/jianzhugongchenglunwen/1873212.html